|
ATS Racing 550 whp complete build ups
ATS Racing
Turn key 550 whp build up
| LABOR |
|
|
|
|
|
|
| HOURS |
SERVICE PERSON |
DESCRIPTION |
RATE PER HOUR |
TOTAL |
| 23.00 |
ATS |
r&r motors |
|
|
75.00 |
1,725.00 |
| 3.00 |
ATS |
assemble long block |
|
|
75.00 |
225.00 |
| 10.00 |
ATS |
tuning AEM |
|
|
75.00 |
750.00 |
| 0.50 |
ATS |
throttle cable bracket |
|
|
75.00 |
37.50 |
| 1.50 |
ATS |
race gas tuning |
|
|
75.00 |
112.50 |
| 6.40 |
ATS |
install dual fuel pumps |
|
|
75.00 |
480.00 |
| 1.30 |
ATS |
install CV's in axles |
|
|
75.00 |
97.50 |
| 2.00 |
ATS |
install gauges |
|
|
75.00 |
150.00 |
| 9.00 |
ATS |
install WTA IC, incl heat exchanger |
|
|
75.00 |
675.00 |
| 2.00 |
ATS |
degree cams on dyno |
|
|
75.00 |
150.00 |
|
|
|
|
|
Labor subtotal |
4,402.50 |
|
|
|
|
|
|
|
| PARTS |
|
|
|
|
Total labor cost |
4,402.50 |
| ITEM |
DESCRIPTION |
QTY |
UNIT COST |
|
| |
RMR 70mm manifold |
|
|
1 |
695.00 |
695.00 |
| |
65mm throttle body with MR2 throttle cam |
|
|
1 |
209.00 |
209.00 |
| |
AEM Standalone |
|
|
1 |
1625.00 |
1625.00 |
| |
AEM wideband |
|
|
1 |
319.00 |
319.00 |
| |
AEM serial gauge |
|
|
1 |
279.00 |
279.00 |
| |
dual gauge pod |
|
|
1 |
39.00 |
39.00 |
| |
Greddy Profec B |
|
|
1 |
319.00 |
319.00 |
| |
ATS 2.2l Stroker short block |
|
|
1 |
2200.00 |
2200.00 |
| |
HKS 264 cams |
|
|
2 |
340.00 |
680.00 |
| |
ATS adjustable cam gears |
|
|
1 |
150.00 |
150.00 |
| |
3 angle valve job |
|
|
1 |
450.00 |
450.00 |
| |
replace exhaust guides |
|
|
8 |
8.00 |
64.00 |
| |
Ferrea Valves |
|
|
16 |
19.50 |
312.00 |
| |
Cut seats for larger valves |
|
|
16 |
8.00 |
128.00 |
| |
ATS valve springs |
|
|
1 |
96.00 |
96.00 |
| |
oil pump, high volume |
|
|
1 |
169.00 |
169.00 |
| |
TTE head gasket |
|
|
1 |
160.00 |
160.00 |
| |
Toyota gasket kit |
|
|
1 |
209.00 |
209.00 |
| |
Wolfkatz rail |
|
|
1 |
325.00 |
325.00 |
| |
Walbro Fuel pump |
|
|
2 |
129.00 |
258.00 |
| |
1150cc injectors |
|
|
4 |
130.00 |
520.00 |
| |
fuel line kit with fittings |
|
|
2 |
149.00 |
298.00 |
| |
L19 head studs |
|
|
1 |
350.00 |
350.00 |
| |
idle air control motor |
|
|
1 |
99.99 |
99.99 |
| |
TPS connectors |
|
|
2 |
14.99 |
29.98 |
| |
MAP sensor 3.5 bar |
|
|
1 |
158.99 |
158.99 |
| |
vacuum fitting for RMR |
|
|
8 |
1.99 |
15.92 |
| |
catch can |
|
|
1 |
99.99 |
99.99 |
| |
ait sensor |
|
|
1 |
39.99 |
39.99 |
| |
ATS 4" intake |
|
|
1 |
150.00 |
150.00 |
| |
ATS CV joints |
|
|
1 |
299.00 |
299.00 |
| |
5 gallons 110 fuel (for tuning) |
|
|
5 |
6.00 |
30.00 |
| |
axle seal |
|
|
2 |
17.99 |
35.98 |
| |
CM stage 4 clutch |
|
|
1 |
499.00 |
499.00 |
| |
flywheel - lightweight |
|
|
1 |
369.00 |
369.00 |
| |
flywheel bolts |
|
|
8 |
6.79 |
54.32 |
| |
ATS GT3582 turbocharger kit |
|
|
1 |
2700.00 |
2700.00 |
| |
WTA intercooler core |
|
|
1 |
499.00 |
499.00 |
| |
blow off valve (typical) |
|
|
1 |
199.00 |
199.00 |
| |
Intercooler charge pipe set |
|
|
1 |
300.00 |
300.00 |
| |
front mount heat exchanger |
|
|
1 |
249.00 |
249.00 |
| |
intercooler water line and fitting kit |
|
|
1 |
219.00 |
219.00 |
| |
intercooler water pump |
|
|
1 |
187.00 |
187.00 |
| |
intercooler reservoir |
|
|
1 |
119.00 |
119.00 |
| |
antifreeze |
|
|
3 |
14.99 |
44.97 |
| |
oil 10w-30 |
|
|
4 |
1.99 |
7.96 |
| |
oil filter - Toyota |
|
|
1 |
7.99 |
7.99 |
| |
Transmission refill kit |
|
|
1 |
59.00 |
59.00 |
| |
Berk Technology 3" exhaust |
|
|
1 |
699.00 |
699.00 |
|
|
|
|
|
Parts subtotal |
17,027.08 |
|
|
|
Tax rate |
8.5 |
%
Tax |
1,447.30 |
|
|
|
|
|
Shop Items |
125.00 |
|
Payments |
|
|
|
|
|
Total |
23,001.88 |
We
have made over 575 whp with this setup at ~27 psi (750 flywheel hp) on Aaron's
2.2 MR2
If
you are shipping the vehicle to/from outside of Texas the sales tax can be
removed. We can provide a shipping service anywhere in the US for approximately
the same cost as the TX sales tax.
This
quote assumes a good condition MR2, with acceptable core parts (block, head,
etc) and a good to excellent condition transmission. If you have any doubts
about the condition of your transmission we recommend purchasing a new LSD
transmission (available below). Also we can offer rebuilt 91-92 style
transmissions or rebuild your transmission and install a more aggressive
aftermarket LSD if you prefer. Other options exist such as ceramic coatings,
engine dress up parts, short shifters and complete suspension upgrades.
Timeframe:
unless special arrangements are made, expect your build to take between 3 and 4
months depending on product availability.
Optional: NEW OEM LSD Transmission with LSD adapter kit MR2 ONLY
$2080
Back to
Parts Main
Back to Service Main
|
